Skip to content
HearingTracker
Log in

Costco apparently fixed my KS10 charge problem

This topic is closed.

13 replies3.4k viewsLast reply

Link to this topic
Edited

I’ve been having intermittent charging problems, so I started making notes. Here’s an excerpt:

9/12, 9:04pm: Easyline showed both aids @33% in charger, R flashed green, L flashed yellow.

9:06pm: Easyline 99% & 33%. Take R out of charger. Easyline showed 99%. Reset R aid back in charger Easyline R 55%.

9:20: L44%, R 61%, which shows both are charging. Later charge finished OK, both aids @ 100%.

9/16 and 9/17 similar problem except with L .

9/18 took aids & charger to Prescott, AZ Costco. Was told a firmware update will be available in a day or two. Left aids (temporarily using old KS7’s).

9/21 Costco calls – aids ready. They gave them back @100% charge and with new receivers (speakers).

I’ve now used the aids 3+ days with no problems. Hopefully the update fixed the problem.

9 people in this conversation4 min readJump to latest
@FredO said:

I’ve now used the aids 3+ days with no problems. Hopefully the update fixed the problem.

I posted that too soon. Last night I charged both aids to slightly over 80% per Easyline and the flashing green lights and then turned both off. This morning, when I plugged the charger, the L was flashing yellow and at only 21%, R at 84%. Resetting the L did not help. It is slowly charging but the problem was not fixed.

@FredO said:

I posted that too soon. Last night I charged both aids to slightly over 80% per Easyline and the flashing green lights and then turned both off. This morning, when I plugged the charger, the L was flashing yellow and at only 21%, R at 84%. Resetting the L did not help. It is slowly charging but the problem was not fixed.

Another update:
In the 17 days since I reported that problem, the charging has worked flawlessly.

I never turn my KS10s off at night. I just put them in the charger. After two years or so, the right one will occasionally flash green when inserted in the charger. I just reinsert it until it flashes yellow.
Once, in the morning, one of them glowed red. I just put it back in the charger and it charged fine.
They keep working and I hope they last as long as I do.
Every morning, I switch from Automatic Premium to Clarity and reduce the volume to -1.

In reply to @FredO

@FredO said:

In the 17 days since I reported that problem, the charging has worked flawlessly.

Still another update: Going on 4 weeks now, the charging problem seems to be gone. The aids have been charging every time.

I understand that your hearing aids are the same as my phonaks. There is a function to reset the battery charging. Hold down the button that powers your aids on & off for about 20-30 seconds, release, and place them in the charger. This resets the charging function to the factory default, which sometimes gets wonky.

I try to remember to do this once a month rather than waiting for a charging problem.

I started having the charging problem after 2 years. I’ll set up the charging when I go to bed and sometimes in the middle of the night I’ll see the unit (usually the right ) still charging/blinking. Sometimes the light is blinking green and sometimes it’s solid red. I do a reset and usually when I wake up it’s OK. Not always. There are times it takes 2 1/2 hours to fully charge. No one seems to have THE answer. :-/

Now I typically charge to ~80-85% before going to bed and then top off in the morning. Lately my charging problem has returned (example below). I called Costco & was told to do a hard reset but that didn’t seem to help. The problem occurs ~every other day. Here’s the most recent. (Worked OK last night.) Maybe another firmware update or back to the factory. Fortunately, I kept my old KS7’s as backups.

2/2 charge L/R to 88/85%, take out of charger L 59%, reset L back in charger to 83%. 2/3, 8am, charge same as at night.

I was having a similar problem. I looked at the contact wires of the charger with a magnifying glass and found they were coated with a thin yellowish varnish that I assume was dried skin or hair oil. I scraped it off with an Exacto knife (with the power disconnected) and the problems went away. Since then I wipe down the contacts and body of the with an alcohol swab before putting them in at night. My audi originally recommended this but I didn’t think it was worth it until the problems started.

In reply to @FredO

Another (hopefully last) update —
I tried cleaning contacts (in addition to my standard practice of rubbing the contacts on my pants) – no help.

I called Costco (in Prescott, AZ). The lady I talked to said my warranty will run out in May and she suggested I bring in the ’s & charger for them to send back to manufacturer for repair. So I have an appt. Sat. to have my settings applied to my previous KS-7’s to use while I’m waiting for the KS-10’s to be returned.

The ’s were returned in less than a week. I got a new charger and probably new KS10 aids. So far, they work.
Unless the problem returns, this will conclude my KS10 adventure.

Edited

I started having this issue this year after using the KS10s for three years. One of them will start having charging issues and may even go completely dead. Both times I have taken them to Costco and they have cleaned and “reset” them. Then they work for a while. I do not think this has to do with the charger or dirty contacts, but probably the battery/charging system is failing to work properly. A reset may restart the charging system, but I suspect the battery is probably aging and affecting charging performance. This time Costco offerered to repair under warranty and admitted there was a charging defect for the KS10s. Time for new .

Had my KS10’s serviced and batteries replaced last May while still under warranty.Fast forward 9 months and the right aid would not charge, left aid ok. Costco sent it for repair £120. I’m now getting around 20 hours of use from a full a charge.

In reply to @arydant

I wouldn’t turn down the replacement under warranty. Maybe you do need new ? But these as a backup would be sweet, esp if you get new HAs in the “repair”.

WH

Related discussions